Trusted heat pump repair for Mineral Wells properties. Same-day service available, transparent pricing, and a workmanship guarantee.
When your heat pump in Mineral Wells, TX fails to maintain setpoint or cycles erratically, KIC Refrigeration technicians trace the fault through the complete refrigerant and electrical circuit. We service single-stage, two-stage, and variable-speed heat pumps from Carrier, Trane, Lennox, Rheem, and Goodman, restoring reliable heating and cooling with same-day repair availability.
Properties throughout Mineral Wells (pop. 16,117) face unique demands when it comes to heat pump repair. Texas heating loads, cooling calculations, and the insulation levels and duct configurations found in Mineral Wells homes all influence the approach we take. KIC Refrigeration tailors every heat pump repair project to the conditions your property actually faces — no generic solutions.
Choosing the right contractor for heat pump repair in Mineral Wells, TX makes all the difference between efficient comfort and a system that short-cycles. KIC Refrigeration uses Manual J load calculations, installs to manufacturer specifications, and backs every project with a warranty. Call (866) 858-2961 to schedule your free assessment.
How our NATE-certified technicians deliver quality heat pump repair results from start to finish.
We test your heat pump in both heating and cooling modes, checking the reversing valve operation, defrost cycle initiation, and auxiliary heat engagement to isolate which mode and component is failing.
At your Mineral Wells property, our technician connects digital manifold gauges and measures suction pressure, discharge pressure, liquid line temperature, and suction line temperature. We calculate superheat and subcooling to determine if the charge is correct or if there is a restriction in the metering device or a refrigerant leak.
KIC Refrigeration repairs your Mineral Wells, TX heat pump with precision. For sealed-system work, we recover refrigerant with a certified recovery machine, braze with nitrogen flowing to prevent scale, pressure test with dry nitrogen to 300 PSI, evacuate to below 500 microns, and weigh in the exact factory charge.
We run the heat pump through complete heating and cooling cycles, verify pressures match the manufacturer chart, confirm the defrost cycle activates correctly, and check the temperature differential across the coil meets specification.
Get answers to the heat pump repair questions our customers ask most often.
Heat pump repair in Mineral Wells typically ranges from $150 to $600 for common component failures like run capacitors, contactors, defrost timers, and condenser fan motors. Reversing valve replacement is a more involved job that runs $800 to $2,000 including refrigerant recovery and recharge. Compressor replacement costs $1,500 to $3,000 depending on the unit tonnage, refrigerant type — whether R-410A or older R-22 — and whether a hard-start kit is needed. KIC Refrigeration provides a detailed written estimate with parts and labor itemized before any work begins at your Mineral Wells property, so you know exactly what the repair will cost.
The general rule is to repair if the system is under 10 years old and the repair costs less than 50 percent of a replacement. Heat pumps over 12 to 15 years old — especially units still running on R-22 refrigerant — are often better replaced with a new R-410A system that offers higher SEER2 and HSPF2 efficiency ratings and lower operating costs. A new variable-speed heat pump can reduce your Mineral Wells energy bills by 30 to 40 percent compared to an aging single-stage unit. KIC Refrigeration gives honest repair-versus-replace advice based on your specific equipment age, condition, and repair history rather than pushing unnecessary replacements.
Heat pump icing is caused by conditions that prevent the defrost cycle from working correctly. The most common culprits are low refrigerant charge from a slow leak, a dirty or blocked outdoor coil that restricts airflow, a failed defrost control board or timer that does not initiate the defrost sequence, a stuck defrost relay, or a malfunctioning outdoor fan motor. In normal operation, the defrost cycle activates every 30 to 90 minutes during cold weather, reversing the system briefly to melt accumulated frost. When any component in this chain fails, ice builds up until the unit shuts down on high-pressure safety. KIC Refrigeration tests the complete defrost circuit and refrigerant charge at your Mineral Wells, TX home to identify and fix the root cause.
KIC Refrigeration provides a comprehensive workmanship warranty on all heat pump repairs performed in Mineral Wells, TX. Replacement parts carry manufacturer warranties that range from 1 to 10 years depending on the component — compressors typically carry 5 to 10 year manufacturer warranties, while electrical components like capacitors and contactors carry 1 to 2 year warranties. If a part we install fails within the warranty period, we replace it at no charge for the part and provide the labor to install it. KIC Refrigeration handles all warranty documentation and claims on your behalf so you never have to chase paperwork. Ask your technician about specific warranty terms during your service appointment.
Hear from property owners who chose us for their heating and cooling needs.
"Smart thermostat installation was seamless. They even helped me pick the right model for my system before the appointment. Very consultative approach."
"Mini split repair was done right the first time. The outdoor unit had a refrigerant leak and they found it, fixed it, and recharged the system same day."
"Emergency HVAC repair at midnight with a newborn in the house. They treated it like the emergency it was and had our heat back on in under two hours."